超声波增湿撞击流泡沫捕捉塔处理含铍废气研究

凡思军; 吴磊; 刘忠英; 姚剑; 马继飞; 李玉兰; 侯惠奇; 谢雷东; 陈堃

doi:10.11889/j.0253-3219.2016.hjs.39.010604

您当前的位置：

首页 >

文章列表页 >

超声波增湿撞击流泡沫捕捉塔处理含铍废气研究

更新时间：2021-05-24

- 超声波增湿撞击流泡沫捕捉塔处理含铍废气研究
- Purification of Be-containing offgas by ultrasonic atomization-impinging stream foam tower
- 核技术 2016年39卷第1期文章编号：010604
- 作者机构：
  
  中国科学院上海应用物理研究所嘉定园区上海 201800
  Shanghai Institute of Applied Physics, Chinese Academy of Sciences, Jiading Campus, Shanghai 201800, China
- 作者简介：
  
  凡思军,男,1976年出生,2012年于中国科学院上海光学精密与机械研究所获博士学位
  李玉兰,E-mail:lyl@sinap.ac.cn
- 基金信息：
- DOI：10.11889/j.0253-3219.2016.hjs.39.010604
  中图分类号： TL426
- 收稿日期：2015-10-08，
  
  录用日期：2015-11-02，
  
  纸质出版日期：2016-01-25
- 稿件说明：
移动端阅览
凡思军, 吴磊, 刘忠英, 等. 超声波增湿撞击流泡沫捕捉塔处理含铍废气研究[J]. 核技术, 2016,39(1):010604

Sijun FAN, Lei WU, Zhongying LIU, et al. Purification of Be-containing offgas by ultrasonic atomization-impinging stream foam tower[J]. Nuclear techniques, 2016, 39(1): 010604
凡思军, 吴磊, 刘忠英, 等. 超声波增湿撞击流泡沫捕捉塔处理含铍废气研究[J]. 核技术, 2016,39(1):010604 DOI： 10.11889/j.0253-3219.2016.hjs.39.010604.

Sijun FAN, Lei WU, Zhongying LIU, et al. Purification of Be-containing offgas by ultrasonic atomization-impinging stream foam tower[J]. Nuclear techniques, 2016, 39(1): 010604 DOI： 10.11889/j.0253-3219.2016.hjs.39.010604.

摘要

采用超声波雾化除尘技术

研制了最大处理风量为300 m

·h

-1

的超声波增湿撞击流泡沫捕捉塔含铍废气处理样机

按照国家标准方法对超声波增湿撞击流泡沫塔的进、出气口进行采样

使用电感耦合等离子谱仪对其除铍性能的影响因素进行了研究。结果表明

雾化加湿量的增加有利于除铍效率的提高

但同时也使净化后气体的绝对湿度增加;超声波加湿器安装在距离塔体3 m以上方能最大限度地提高除铍效率;当颗粒物粒径在0.4 μm以上时

除铍效率较高

而在0.4 μm以上时

除铍效率显著降低;除铍效率随进气口初始铍浓度而增加;气体流速的增加有利于提高除铍效率

但气体流速过高将导致净化后气体绝对湿度显著增加

最佳气体流速为12 m·s

-1

。当气体流速为12 m·s

-1

时

最佳塔内水位为40 cm。研究结果为超声波增湿撞击流泡沫捕捉塔在钍基熔盐堆(Thorium Molten Salt Reactor

TMSR)核能系统项目含铍废气上的应用提供了实验依据。

Abstract

Background:

LiF-BeF

is used as coolants for Thorium Molten Salt Reactor (TMSR). The offgas from TMSR containing beryllium which is harmful to both human health and the environment must be purified before being discharged.

Purpose:

A new type wet duster-ultrasonic atomization-impinging stream foam tower

was developed.

Methods:

The beryllium removal properties were investigated by sampling according to national standards. The increase of atomization amount is helpful for improving beryllium removal efficiency.

Results:

In order to control the absolute humidity offgas after purification

the optimal atomization amount is set at 80 mL·min

-1

. The ultrasonic humidifier should be installed 3 m away from the foam tower. Particles with diameter bigger than 0.4μm can be removed effectively. The beryllium removal efficiency of offgas increases with the initial beryllium concentration and the offgas velocity which is optimized at 12 m·s

-1

. The optimal water level in the tower is 40 cm when the offgas velocity is 12 m·s

-1

Conclusion:

The results indicate that ultrasonic atomization-impinging stream foam tower is suitable for purifying offgas containing beryllium in TMSR.

关键词

Keywords

references

江绵恒 , 徐洪杰 , 戴志敏 . 未来先进核裂变能——TMSR核能系统 . 中国科学院院刊 , 2012 . 27 ( 3 ): 366 - 374 .

JIANG Mianheng , XU Hongjie , DAI Zhimin . Advanced fission energy program-TMSR nuclear energy system . Bulletin of the Chinese Academy of Sciences , 2012 . 27 ( 3 ): 366 - 374 .

张宁 , 郭冰 , 韩立欣 , . TMSR硝酸盐自然循环回路控制系统设计 . 核技术 , 2015 . 38 ( 7 ): 070401 .

ZHANG Ning , GUO Bing , HAN Lixin , . Design of nitrate natural circulation loop control system in TMSR . Nuclear Techniques , 2015 . 38 ( 7 ): 070401 .

李华 , 尹俊连 , 张宁 , . 不同背压下旋流式气液分离器工作特性 . 核技术 , 2015 . 38 ( 1 ): 010603 .

LI Hua , YIN Junlian , ZHANG Ning , . Performance of a gas-liquid separator under different back pressure . Nuclear Techniques , 2015 . 38 ( 1 ): 010603 .

刘可 , 徐良 , 刘哲 , . 不同温度 FLiNaK 熔盐对 Hastelloy-N . 核技术 , 2015 . 38 ( 2 ): 020602 .

LIU Ke , XU Liang , LIU Zhe , . Impact of temperature on the molten salt corrosion of Hastelloy-N alloys . Nuclear Techniques , 2015 . 38 ( 2 ): 020602 .

汪洋 , 唐忠锋 , 谢雷东 , . 高温氟化盐对熔盐堆用材料的腐蚀行为研究进展 . 化学通报 , 2013 . 76 ( 4 ): 307 - 312 .

WANG Yang , TANG Zhongfeng , XIE Leidong , . The research progress of corrosion behavior of materials for molten salt reactors in high temperature molten fluorides . Chemistry Online , 2013 . 76 ( 4 ): 307 - 312 .

Grimes W . Molten-salt reactor chemistry . Nuclear Technology , 1970 . 8 ( 2 ): 137 - 155 .

Williams D . Assessment of candidate molten salt coolants for the NGNP/NHI heat-transfer loop . Tennessee: Oak Ridge National Laboratory , 2006 .

GB 16297-1996, 大气污染物综合排放标准 . 1996 .

GB 16297-1996, Integrated emission standard of air pollutants . 1996 .

GB 8978-1996, 污水综合排放标准 . 1996 .

GB 8978-1996, Integrated wastewater discharge standard . 1996 .

GBZ 2.1-2007, 工作场所有害因素职业接触限值第1部分: 化学有害因素 . 2007 .

GBZ 2.1-2007, Occupational exposure limits for hazardous agents in the workplace-chemical hazardous agents . 2007 .

胡满银 , 赵毅 , 刘忠 . 除尘技术 . 北京: 化学工业出版社 , 2006 . 182 - 219 .

HU Manyin , ZHAO Yi , LIU Zhong . Dust removal technology . Beijing: Chemical Industry Press , 2006 . 182 - 219 .

吴源道 . 铍-性质、生产和应用 . 北京: 冶金工业出版社 , 1986 . 77 - 86 .

WU Yuandao . Beryllium properties, production and application . Beijing: Metallurgical Industry Press , 1986 . 77 - 86 .

凡凤仙 , 张明俊 . 蒸汽相变凝结对 PM 2.5 粒径分布的影响 . 煤炭学报 , 2013 . 38 ( 4 ): 694 - 699 .

FAN Fengxian , ZHANG Mingjun . Influence of vaper heterogeneous condensation on the PM 2.5 particle size distribution . Journal of China Coal Society , 2013 . 38 ( 4 ): 694 - 699 .

沈胜强 , 甄妮 , 牟兴森 , . 丝网除沫器除沫效率的数值模拟 . 核动力工程 , 2014 . 35 ( 5 ): 172 - 177 .

SHEN Shengqiang , ZHEN Ni , MU Xingsen , . Determination of separation efficiency in wire mesh mist eliminator by CFD . Nuclear Power Engineering , 2014 . 35 ( 5 ): 172 - 177 .

郭朝有 , 贺国 , 王小川 , . 高温气流中丝网除水特性数值研究 . 武汉理工大学学报(交通科学与工程版) , 2014 . 38 ( 5 ): 1036 - 1039 .

GUO Chaoyou , HE Guo , WANG Xiaochuan , . Numerical simulation of water elimination by wire mesh in hot gas stream . Journal of Wuhan University of Technology (Transportation Science & Engineering) , 2014 . 38 ( 5 ): 1036 - 1039 .

李群生 . 新型高效丝网除雾器的原理与应用 . 明胶科学与技术 , 2005 . 24 ( 2 ): 99 - 102 .

LI Qunsheng . The research and application of new style high efficient mesh mist eliminator . The Science and Technology of Gelatin , 2005 . 24 ( 2 ): 99 - 102 .

Brunazzi E , Paglianti A . Design of complex wire-mesh mist eliminators . AIChE Journal , 2000 . 46 ( 6 ): 1131 - 1137 .

Brunazzi E , Paglianti A . Conventional and complex knitted mesh mist eliminators . Chemical Engineering & Technology , 2001 . 24 ( 11 ): 1199 - 1204 .

Eddie S A , Helsør T , Svendsen H F . Liquid holdup in wire-mesh pads . Chemical Engineering Research and Design , 2010 . 88 ( 11 ): 1523 - 1531 .

U.S. 7291196, Filamentary pad for improved mist elimination and mass transfer . 2007 .

Helsør T , Svendsen H . Experimental characterization of wire mesh demisters . Trondheim: Norwegian University of Science and Technology , 2006 .

Setekleiv A E , Svendsen H F . Operation and dynamic behavior of wire mesh pads . Chemical Engineering Science , 2012 . 68 ( 1 ): 624 - 639 .

Al-Dughaither A S , Ibrahim A A , Al-Masry W A . Investigating droplet separation efficiency in wire-mesh mist eliminators in bubble column . Journal of Saudi Chemical Society , 2010 . 14 ( 4 ): 331 - 339 .

陈卓楷 . 超声雾化水雾的除尘机理和在实验中的应用研究 . 广州: 广州工业大学 , 2007 .

CHEN Zhuokai . The mechanism study of atomization water made by ultrasonic technique in dust removal experiment . Guangzhou: Guangzhou University of Technology , 2007 .

GB/T 16157-1996, 固定污染源排气中颗粒物测定与气态污染物采样方法 . 1996 .

GB/T 16157-1996, Determination of particulates and sampling methods of gaseous pollutants emitted from exhaust gas of stationary source . 1996 .

HJ 657-2013, 空气和废气颗粒物中铅等金属元素的测定电感耦合等离子体质谱法 . 2013 .

HJ 657-2013, Ambient air and stationary source emission-detection of metals in ambient particle matter- inductively coupled plasma/mass spectrometry (ICP-MS) . 2013 .

GB 11605, 湿度测量方法 . 2013 .

GB 11605, Measurement method of humidity . 2013 .

顾崇孝 . 无溢流泡沫除尘器的设计与应用 . 有色金属设计 , 1997 . 24 ( 3 ): 30 - 34 .

GU Congxiao . Design and application of no overflow foam dust collector . Nonferrous Metals Design , 1997 . 24 ( 3 ): 30 - 34 .

刘社育 , 蒋仲安 . 湿式除尘器除尘机理的理论分析 . 中国矿业大学学报 , 1998 . 27 ( 1 ): 47 - 50 .

LIU Sheyu , JIANG Zhongan . Theoretical analysis of dedust mechanism of wet scrubbers . Journal of China University of Mining and Technology , 1998 . 27 ( 1 ): 47 - 50 .

裴清清 , 张旭东 , 魏先勋 . 三种型式的湿式除尘器性能对比试验 . 环境科学学报 , 1997 . 17 ( 1 ): 106 - 109P .

PEI Qingqing , ZHANG Xudong , WEI Xianxun . An comparative study on three kind of wet dust collector . Acta Scientiae Circumstantiae , 1997 . 17 ( 1 ): 106 - 109P .

浏览量

下载量

CSCD

文章被引用时，请邮件提醒。

提交

工具集

关联资源

SGL-83型滤料效率测试装置的研究