Study on the bubble movement and breakup of Venture-type bubble generator in throat and expansion section

Zhaowei MA; Hua LI; Wei LIU; Guimin LIU; Qin ZHANG; Guo YANG; Fei WEI

doi:10.11889/j.0253-3219.2018.hjs.41.110602

您当前的位置：

首页 >

文章列表页 >

Study on the bubble movement and breakup of Venture-type bubble generator in throat and expansion section

NUCLEAR ENERGY SCIENCE AND ENGINEERING | 更新时间：2021-05-19

- Study on the bubble movement and breakup of Venture-type bubble generator in throat and expansion section
- NUCLEAR TECHNIQUES Vol. 41, Issue 11, Article number: 110602(2018)
- 作者机构：
  
  1.中国科学院上海应用物理研究所上海 201800
  2.中国科学院大学北京 100049
- 作者简介：
- 基金信息：
  
  Strategic Priority Research Program of Chinese Academy of Sciences
- DOI：10.11889/j.0253-3219.2018.hjs.41.110602
  CLC： TL334
- Received：21 August 2018，
  
  Revised：16 September 2018，
  
  Published：10 November 2018
- 稿件说明：
移动端阅览
Zhaowei MA, Hua LI, Wei LIU, et al. Study on the bubble movement and breakup of Venture-type bubble generator in throat and expansion section[J]. Nuclear techniques, 2018, 41(11): 110602
DOI：

Zhaowei MA, Hua LI, Wei LIU, et al. Study on the bubble movement and breakup of Venture-type bubble generator in throat and expansion section[J]. Nuclear techniques, 2018, 41(11): 110602 DOI： 10.11889/j.0253-3219.2018.hjs.41.110602.

摘要

文丘里式气泡发生器因其结构简单、能够有效产生所需均匀粒径的微气泡等优点，被熔盐堆脱气系统所采用。本文在脱气回路水力试验台架的实验基础上，借助高速相机来研究气泡在文丘里气泡发生器喉部和扩张段处的运动和碎化特性。研究表明：气泡运动可以分为4个阶段：1）气泡高速稳定运动阶段；2）气泡速度剧烈变化阶段；3）气泡速度稳定波动阶段；4）气泡低速稳定运动阶段。随着进气孔径的增大气泡在上述4个阶段的稳定性增加；随着水流量的增加，第二和第三阶段的区域将会向靠近

=0 mm处缩小。其中气泡的碎化过程主要是在第二阶段发生的。

Abstract

Background

The Venturi-type bubble generator is adopted in molten salt reactor degassing system because of its advantages of simple structure and effective production of micro-sized bubbles.

Purpose

This study aims to investigate the motion and breakup characteristics of bubbles in the throat and expansion section of Venturi-type bubble generator.

Methods

Based on the experimental water loop

high speed camera was employed to measure the movement of bubbles. The velocity distribution of bubbles in the throat and expansion section were analyzed

and compared with water velocity distribution without gas inlet.

Results

Bubble motion was divided into four stages:high-speed stable motion stage; rapid change stage; stable fluctuation stage; low-speed steady motion stage. With the increase of the gas inlet diameter

the fragmentation rate of the bubble decreases

and the stability of the bubble increases in the above four stages. As the water flow increases

the areas in the second and third stages will shrink to near

=0 mm.

Conclusion

The fragmentation of bubbles is related to the distribution of bubbles in the throat and expansion section of Venture-type bubble generator. The higher the velocity of the bubble changes

the greater the degree of fragmentation of the bubble

and the breakup process of bubbles occurs mainly in the second stage.

关键词

Keywords

references

Robertson R C. MSRE design and operation report I[R]. ORNL-0728, U.S. Atomic Energy Commission, 1965: 205-243.

Robertson R C. Two-fluid molten-salt breeder reactor design study[R]. ORNL-4528, U.S. Atomic Energy Commission, 1970.

Robertson R C. Conceptual design study of a single-fluid molten-salt breeder reactor[R]. ORNL-4541, U.S. Atomic Energy Commission, 1971.

唐文偲 , 阎昌琪 , 孙立成 , . 文丘里式气泡发生器气泡碎化特性研究 . 原子能科学技术 , 2014 . 48 ( 5 ): 844 - 848 . http://d.old.wanfangdata.com.cn/Periodical/yznkxjs201405014 .

Wencai TANG , Changqi YAN , Licheng SUN , . Characteristics of bubble breakup in venturi-type bubble generator . Atomic Energy Science and Technology , 2014 . 48 ( 5 ): 844 - 848 . http://d.old.wanfangdata.com.cn/Periodical/yznkxjs201405014 .

J O Hinze . Fundamentals of the hydrodynamic mechanism of splitting in dispersion processes . American Institute of Chemical Engineers , 1955 . 1 ( 3 ): 289 - 295 . DOI: 10.1002/(ISSN)1547-5905 http://doi.org/10.1002/(ISSN)1547-5905 .

Cottrell W B. Operation of aircraft reactor experiment[R]. ORNL-1854, U.S. Atomic Energy Commission, 1955.

居晓峰 , 孙立成 , 唐文偲 , . 文丘里式气泡发生器工作特性分析 . 核技术 , 2014 . 37 ( 12 ): 120605 DOI: 10.11889/j.0253-3219.2014.hjs.37.120605 http://doi.org/10.11889/j.0253-3219.2014.hjs.37.120605 http://www.j.sinap.ac.cn/hejishu/CN/abstract/abstract324.shtml .

Xiaofeng JU , Licheng SUN , Wencai TANG , . Analysis of the operating characteristics of a Venturi-type bubble generator for MSR . Nuclear Techniques , 2014 . 37 ( 12 ): 120605 DOI: 10.11889/j.0253-3219.2014.hjs.37.120605 http://doi.org/10.11889/j.0253-3219.2014.hjs.37.120605 http://www.j.sinap.ac.cn/hejishu/CN/abstract/abstract324.shtml .

A Kaneko , Y Nomura , S Takagi , . Bubble break-up phenomena in Venture tube . The Japan Society of Mechanical Engineers (B) , 2012 . 2 ( 78 ): 207 - 217 . https://link.springer.com/article/10.1007%2Fs10494-012-9398-8 .

莫政宇 , 杜敏 , 孙立成 , . 底含气率条件下文丘里管气泡发生器内气泡碎裂过程研究 . 核动力工程 , 2016 . 37 ( 6 ): 41 - 44 . http://kns.cnki.net/KCMS/detail/detail.aspx?filename=HDLG201606010&dbname=CJFD&dbcode=CJFQ .

Zhengyu MO , Min DU , Licheng SUN , . Investigation on bubble breakup in a Venturi-tube bubble generator under low gas fraction condition . Nuclear Power Engineering , 2016 . 37 ( 6 ): 41 - 44 . http://kns.cnki.net/KCMS/detail/detail.aspx?filename=HDLG201606010&dbname=CJFD&dbcode=CJFQ .

X Yu , P Felicia . Optimization of cavitation venturi tube design for pico and nano bubbles generation . International Journal of Mining Science and Technology , 2015 . 25 ( 4 ): 523 - 529 . DOI: 10.1016/j.ijmst.2015.05.002 http://doi.org/10.1016/j.ijmst.2015.05.002 .

J J Li , Y C Song , J L Yin , . Investigation on the effect of geometrical parameters on the performance of a Venturi type bubble generator . Nuclear Engineering and Design , 2017 . 325 90 - 96 . DOI: 10.1016/j.nucengdes.2017.10.006 http://doi.org/10.1016/j.nucengdes.2017.10.006 .

R S Azad . Turbulent flow in a conical diffuser:a review . Experimental Thermal and Fluid Science , 1996 . 13 ( 4 ): 318 - 337 . DOI: 10.1016/S0894-1777(96)00091-X http://doi.org/10.1016/S0894-1777(96)00091-X .

Views

下载量

CSCD

Alert me when the article has been cited

提交

Tools

Publicity Resources

Analysis of the operating characteristics of a Venturi-type bubble generator for MSR

Related Author

JU Xiaofeng

SUN Licheng

TANG Wencai

YUN Hongyu

YAN Changqi

Related Institution

Fundamental Science on Nuclear Safety and Simulation Technology Laboratory, Harbin Engineering University

College of Hydraulic and Hydra-electric Engineering, Sichuan University

AI问答

Address：2019 Jialuo Road, Jiading, Shanghai, China Postal code：201800
Tel：021-39194977 Email：LHB@sinap.ac.cn
Technical support is provided by Beijing Founder electronics co., LTD 沪ICP备05005479号-1 京公网安备11010802024621
It is recommended to read the content of this site in Chrome&IE9+. Please switch to extreme mode in browser 360.
Cookies We use cookies to help provide and enhance our service and tailor content. By continuing, you agree to the use of cookies.
Total Visits：880473

⁰